HVP Security Shutters - Roller shutter manufacture and installation
Logos of the Door and Hardware Federation, Moody International and Worksafe Get a Quote

Page in development. Apologies for any inconvenience. Back «

Firecurtain

Certified fire rated roller shutters

Fire curtains from HVP are designed to automatically close in the event of a fire. They seal off the opening they sit over and prevent the spread of fire. Our fire shutters have a rating of 1 to 4 hours.

Fire curtain firecurtains are thoroughly tested and conform to strict standards (see the technical specification for more information).

In addition all our fire shutter installation engineers are FIRAS trained and accredited. This means they know how to correctly install fire shutters so it performs as intended. Read more about our FIRAS accreditation.

The main purpose of a fire shutter is to prevent or slow down the spread of fire. Next to this it can also be used as a security shutter. Fireshutters from HVP have a solid lath and are similar in appearance to our Screenguard security roller shutters.

The pictures below show a typical FS75 Fire Shutter installation.

Fire curtain FS75 Face View Fire curtain FS75 Side View Fire curtain FS75 Rear View Fire curtain Fire Detection Inface Panel Fire curtain FS75 Expansion Slots Fire curtain FS75 Warning Panel and Motor Box Fire curtain FS75 Soldered Fusible Link Fire curtain FS75 Motor Housing

Fire curtain fireshutter technical specification

abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL

Technical Specification Fire curtain FS75 fire shutter

A block motor fire-resisting roller shutter

Construction:

abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL

Operation:

abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL

Release Meachnisms:

abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL

Finish:

abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL

Size Guide:

Maximum Size: 8000mmW x 6000mmH

Contact HVP at 01392 270218 for shutter weights or any other questions you may have. We'll be happy to assist.

Technical Specification Fire curtain FS50 fire shutter

A tubular motor fire-resisting roller shutter

Construction:

Manufactured from 50mm flat (up to *4000mmW) or 75mm curved (up to *4800mmW) galvanised steel lath. Galvanised steel T section bottom rail. Galvanised mild steel guides, 50mm u-section up to 4000mmW or 65mm u-section up to 4800mmW.

*Note: the maximum width will reduce according to the height.

Operation:

Electric operation by single phase tubular motor. A safety brake fitted when required to comply with BS EN 13241:2003-1.

Release Meachnisms:

Generally linked to the fire alarm through a fire relay. Upon receipt of a Volt-free signal from the fire alarm, the shutter is powered down. The shutter requires a maintained power supply, and is supplied with a battery backup in case of mains power failure. A fusible link or localised smoke/heat detector can be used as a backup to activate the shutter or as an alternative when a fire alarm signal is not available.

Finish:

Galvanised self colour finish with one coat primer paint on end plates, angles and barrel; can be polyester powder coated to any RAL colour (subject to availability).

Size Guide:

  • Minimum width: 800mmW overall endplates
  • Maximum Sizes: Up to 4800mmW and up to 3850mmH
  • Maximum overall area: 10 square metres. For larger areas use the FS75 fire shutter.

Contact HVP at 01392 270218 for shutter weights or any other questions you may have. We'll be happy to assist.

Technical drawings firecurtains

Below are technical drawings of firecurtains in various arrangements. Hover over the images for more detail.

Technical description Fire curtain roller shutter

abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL

Security and fire resistance

abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL MNO PQRS TUV WXYZ ! "§ $%& /() =? * '<> |; ²³~ @`΄ ©«» €ΌΧ {} abc def ghi jkl mno pqrs tuv wxyz ABC DEF GHI JKL

Many firecurtains perform a double function. Next to automatically closing in the event of a fire, they are used as everyday security shutters, very similar to our Screenguard roller shutter.

Downloads Fire curtain fire shutters

Below you'll find technical drawings, specification texts and our Fire curtain fire shutter brochure to download. If you require any further information or need any assistance regarding our fire shutters, please contact us. We'll be happy to help.

© 2017 HVP Security Shutters | About this website | Feedback | info@hvpshutters.co.uk